Excellent ignition coils factory

Vehicle ignition coil provider today: The service life of an ignition coil depends on several factors such as driving style, the maintenance condition of the vehicle and the type of ignition coil. On average, the service life of an ignition coil is between 60,000 and 100,000 kilometers. However, a regular maintenance check can help to extend the service life. Early cars came with one ignition coil. This coil pack was contained in a part called the distributor which was essentially a bundle of wires leading to each spark plug. The distributor was also responsible for timing each fuel ignition and could become de-calibrated over time, causing the engine to run out of sync. Around the 1980s, automakers began installing electronic sensors to handle ignition timing, and multiple ignition coils for better power and efficiency. Nowadays, most engines have an ignition coil placed directly on top of each spark plug. This is known as “coil on plug” configuration. This type of ignition coil is the most commonly installed in more modern vehicles today. This is because the advantage over other types of ignition coils is that the ignition energy can be transferred to the spark plug with virtually no loss. Find extra info at ignition coil suppliers.

Gasoline vehicles are usually powered by a simple 12-volt DC battery. This is enough voltage to engage a starter motor and get the engine turning, but it’s not enough for actual combustion. (A spark plug needs around 40,000 volts for combustion.) That’s where the ignition coil comes in. It contains a step-up transformer (also known as a coil pack) to convert that tiny current into quick bursts of several thousand volts at a time. This electricity is then sent to each spark plug in perfect time with the cylinder’s combustion cycle, igniting fuel vapor with oxygen and producing power. Diesel engines notably lack ignition coils because they ignite their fuel using heat and pressure alone.

What is the reason? Here are some of them: The spark plug gap is too large, adjust the gap or replace the spark plug; The gasoline quality is not good, try changing to a higher-grade gasoline; The cylinder compression ratio is wrong, adjust the compression ratio; If there is a program failure on the computer board, you can go to the repair shop to test the car with a computer and clear the error message. If it doesn’t work, there may be a problem with your car’s transmission. Total of 8 R&D personnel in our factory, Haiyan wholesale ignition coil suppliers have more than 15 years of working experience.

Using a collapsing magnetic field to induce an electric current: When a magnetic field has been created by applying an electric current to a coil of wire, any change in the electric current (increase or decrease in current flow) creates the same change in the magnetic field. If the electric current is switched off, the magnetic field will collapse. The collapsing magnetic field will then induce an electric current into the coil. If an electric current used to create a magnetic field is switched off, the magnetic field collapses, which induces another electric current into the coil.

The Kettering ignition system became virtually the only type of ignition system for mass-produced petrol cars, and stayed that way until electronically switched and controlled ignition systems started to replace mechanical ignition systems during the 1970s and 1980s. The basic principle of an ignition coil: To produce the required high voltages, ignition coils make use of the relationships that exist between electricity and magnetism. When an electric current flows through an electrical conductor such as a coil of wire, it creates a magnetic field around the coil (Figure 2). The magnetic field (or, more precisely, magnetic flux) is effectively a store of energy, which can then be converted back into electricity.

The engine coil is the main product of Haiyan ignition coil wholesale supplier. Haiyan insists on the use of high-quality materials and advanced technology to manufacture car engine coil. Besides, we strictly monitor and control the quality and cost of each auto ignition coil production process. All this guarantees the auto ignition coil to have high quality and favorable price. According to the function, the auto repair tool cabinet can be divided into mobile tool cabinets and wall tool cabinets. Wheels are installed under the mobile tool cabinet for convenient movement. Haiyan wholesale metal tool cabinet is a shelf like a closet. Discover even more details on hj-auto.com.

Haiyan car ignition coil suppliers have 200 workers, around 170 work over 4 years, with an independent long-term workflow and productivity, have one department including 30 products technology development and research. Our automotive ignition coil manufacturers cover over 14000 square meters, have been awarded city contracts and keeping promises to units, also we certify ISO9001, and TS16949 for a quality system, truly achieving the quality first, reputation first quality service for our customers at home and abroad. Kindly welcome domestic and overseas patrons to come and guide.